Daihatsu Hijet — MOT statistics 2024

The Daihatsu Hijet failed 41.8% of 909 first MOT attempts in 2024 ("first-time", excluding retests). Adjusted for the age of the fleet, its initial-failure ratio is 111.5 (100 = expected for its age profile). This car fails its MOT about 12% more often than expected for its age. Small sample — treat with care.

Age-adjusted peer: Peugeot 306 (index 111.4) — the two published results are 0.1 index points apart.

Daihatsu Hijet common problems: what actually fails the MOT

Lamps, reflectors and electrical equipment stand out at 73.3 per 100 tests, against 36.1 per 100 tests across UK vehicles of the same ages.

higher bar = fails more oftenrate per 100 tests

family vs national — matched to UK vehicles of the same ages — top component groups, per 100 tests. Legend: This family · National avg. Combined labels: family / national average. A gap here reflects how these vehicles are driven, used and maintained as well as how they were built — an MOT defect is a test outcome, not a breakdown.

Named defects ranked by how much more often they appear than the national average — not by raw rate.

Daihatsu Hijet MOT advisories: what gets flagged

Suspension is highest at 48.3 per 100 tests; Emissions & leaks are lowest at 6.7 per 100 tests — the gap is 41.6 per 100 tests.

higher bar = flagged more oftenadvisory items per 100 initial tests

Advisories are wear the tester noted but didn't fail — what will need money soon.

If a car like this fails, does it fail again?

A failure rate does not say whether a failure is a one-off or the start of something. This follows the same vehicles into their next ordinary MOT a year later — retests after a repair are excluded, because they follow a failure by definition. 2019-2024.

A failed test does not clearly change next year's odds here (36.9% against 38.9%): the difference is within the margin of error. The failure most likely to come back is noise, emissions and leaks — 37.7% of those vehicles fail again next year. Some of this is the vehicle and some is the owner: a car that was let go once tends to be let go again. One caveat: a car that fails may be sold or scrapped rather than tested again, so these figures describe the vehicles that came back.

Adjusted for how much these are actually driven

The headline index adjusts for the fleet's age. Wear, though, follows mileage: a three-year-old taxi and a three-year-old garage queen sit in the same age band. These two rows compare every car with vehicles of the same age, and then with vehicles of the same age and the same annual mileage, 2019-2024, on 6,401 tests. Both stand on the six-year corpus so they are measured on identical data — compare them with each other, not with the headline index above, which is measured on 2024 alone.

Split by how much each car is driven. This is a split by annual mileage, not by body type — the MOT record does not say whether a car is a conversion. Within each band the index compares with vehicles of the same age driven as much.

Mileage matters here: matching on how much these are driven moves the figure by 14.2 points — this fleet is driven less than the vehicles it is measured against, so the age-only view flatters it — but it does not change which side of normal the car sits on. One limit to keep in mind: mileage is partly a result of how often a car breaks down — one that spends weeks in the workshop covers fewer miles — so the mileage-matched figure can understate a real weakness. Tests with no usable odometer reading are left out of it.

How the Daihatsu Hijet compares with cars of its own age and size

Not against the whole fleet — against cars of the same size class tested at the same age, 2019-2024.

Raw first-time failure rates within each age, so fleet age cannot flatter either side. A positive difference means this model fails more often than its own class at that age.

How does the Daihatsu Hijet perform as it gets older?

The Hijet at age 20 stands out at 44.2%, against 41.0% for all vehicles of the same age.

higher = larger sharecompare shares in percentage points

Chart axes: car age, years · failure-rate scale 0–48%.

Takeaway: solid line: this family; dashed: all cars.

How dangerous are Daihatsu Hijet MOT failures?

Major defects stand out at 159.2 per 100 tests, against 52.8 per 100 tests nationally.

higher bar = fails more oftenrate per 100 tests

Chart values: Minor 32.8 · Major 159.2 · Dangerous 17.0.

Per 100 tests on this family. National average: Minor 14.2 · Major 52.8 · Dangerous 11.2 per 100.

Does the month of a Daihatsu Hijet MOT matter?

Dec is highest at 50.4%; Feb is lowest at 43.2% — the gap is 7.2 percentage points.

higher = larger sharecompare shares in percentage points

Chart scale: 27%–52%.

bars: Daihatsu Hijet · dashed: all class-4 cars

Takeaway: the spread between best and worst month is 7.2 percentage points — noticeable seasonality. Seasonality partly reflects registration-date clustering, not weather.

Before reading the shape: most of it is not about cars. Britain changes its registration plates twice a year, and 18.9% of these cars were first registered in March with another17.1% in September — 36% in two months against the 17% an even spread would give. An MOT falls due three years after first registration, so the buying calendar becomes the testing calendar. That shapes how many cars are tested each month — not how often they fail: the busiest months here are not the worst ones, so read the failure line on its own and the volume behind it separately.

Daihatsu Hijet average mileage by age

At age 20+, the middle half of Hijets runs from 44,494 miles to 79,923 miles, against 61,465 miles as the median.

further right = more milesmedian is the typical car; band is p25–p75

Does high mileage mean more Daihatsu Hijet MOT failures at the same age?

Within the same age group, split by odometer (2024 MOTs), so this separates wear from age: at ages 15+, 32.7% of those with under 40,000 miles failed first time versus 44.9% of those with 70,000–100,000 miles.No clear mileage gap inside this age group, among cars still being tested.

line: median · band: middle half of the fleet (p25–p75)

A typical 20+-year-old Hijet has ~61,465 miles on the clock. Much more — ask why; much less — check for gaps in the MOT history.

Where in Britain the Daihatsu Hijet fails its MOT most

Brighton area is highest at 64.8%; Birmingham area is lowest at 34.2% — the gap is 30.7 percentage points.

higher = larger sharecompare shares in percentage points

Every dot is a postcode area — size = how many were tested there, colour = share failing. These figures are not age-adjusted: coastal and rural areas often run older fleets and salted roads, so higher raw fail rates do not automatically mean a worse local stock of this model.

Map labels: Scotland · N. England · Wales · London · S. West.

How many miles does a Daihatsu Hijet last?

100,000+ miles stands out at 9.8%.

higher = larger sharecompare shares in percentage points

Of 6,751 tests of this family with a usable odometer in 2024, 9.8% had reached 100k miles. This is a cross-section of cars still presenting for MOT, not a full birth cohort.

Daihatsu Hijet faults that come together

Seatbelts & SRS + Suspension stand out at 4.12×, against 1.00× if the faults were independent.

above 1.0× = more than expectedbelow 1.0× = less

Defects in «Body, chassis, structure» and «Lamps, reflectors and electrical equipment» appear together 2.03× more often than chance (521 co-occurrences in the same test; lift≥1.3, n≥500).

Lift = how many times more often both groups appear on the same test than if independent. A pair is listed from 5 tests with both faults; the lift is shown from 20, and called above chance only when its 95% interval excludes 1 (see rough estimates).

Which Daihatsu Hijet engine is best?

petrol 1.2–1.5 is highest at 102.4; petrol under 1.0 is lowest at 93.3 — the gap is 9.1 points.

below 100 is betterabove 100 is worse100 = normal for this model at that age

Splitting this model by fuel alone hides the thing that actually differs. Within the same badge, the petrol 1.2–1.5 runs at 102.4 against this model's own age norm while the petrol under 1.0 runs at 93.3 — a spread of 9.1 points between two cars that share a name.

Read this one with more care than the rest of the page. Age is held constant, but who buys which engine is not: the largest capacity in a range is often a performance or executive variant that is garaged, cherished and lightly driven, while the smallest is frequently a fleet or entry car worked hard from new. The gap below is real in the test records; how much of it is the engine and how much is the owner, this data cannot separate. Bands under 100 tests are not shown; bands under 5,000 tests are rough estimates.

Daihatsu Hijet MOT repair costs

The MOT-failure repair budget per test runs from £243.10 to £461.89, against £54.85 for the test itself.

bigger number = costs morepounds per test, MOT-failing faults only

Multiply how often each component fails on this model by what that repair usually costs, and you get the amount an owner should expect to budget per test for MOT-failing faults only — roughly £243 to £462, on top of the test fee itself. It is a budgeting figure, not a quote: the spread between a set of pads and a set of discs is most of the range.

Prices are modal quotes from a hand-kept catalogue of published UK garage guides — we do not scrape the booking sites, their terms forbid it, so this list is short and updated by hand with a source and date against each line. Each line prices one typical repair in that group, not a full remedy, and only groups our catalogue actually covers are counted. The contrast worth noticing is the second card: the legal maximum for the test has been £54.85 since 2010, while the repairs it uncovers have followed inflation the whole time.

For scale from a different direction: Warrantywise, which sees used-car warranty claims rather than test failures, puts the average claim at £2,052 across the ten highest-claim models it ranks and £539 for Honda, the lowest-claim make in its index (Warrantywise index 2026, 1.6 million claims, cars aged 3–15). Those sit an order of magnitude above the figures in this table, and the gap is the point: a warranty claim is a gearbox or an engine, which almost never fails an MOT, while the faults that do fail one are corrosion, lamps and tyres, which no warranty pays for. The two numbers answer different questions and neither replaces the other.

Daihatsu Hijet rust problems: where they corrode

Age-standardised corrosion susceptibility stands out at 1.53×, against 1.00× for the national age-standardised rate.

above 1.0× = rusts more than averagebelow 1.0× = rusts less

This Daihatsu Hijet fails on corrosion more often than average once age is held constant, and its owners live in areas that are about typical for the models we publish. Those two point in opposite directions, which is the informative case: it rusts more than average despite living in gentler places, so the cause is the car, not the postcode.

Corrosion is the one failure mode that is as much about geography as about the car. We keep the two apart on purpose: a model can look rusty simply because it is popular in Scotland, and a model can look clean simply because it is bought in Surrey. Blending them into a single score would hide which of the two is doing the work.

Exposure is this model's tests weighted by an area corrosion index built from frost days, salt load and distance to the coast — the composite validated at r = 0.42 against corrosion defects we actually record. It is published as a rank, not a raw score, because every mainstream model skews towards low-corrosion areas for the simple reason that most of Britain's cars are in the south. Susceptibility is standardised to the national age profile, so an old fleet does not get labelled a rusty model.

Does a Daihatsu Hijet advisory become a failure?

Brakes are highest at 24.1%; Tyres are lowest at 7.6% — the gap is 16.5 percentage points.

higher = more likelypercentage is the observed transition probability

chance the same component fails at the next MOT, given an advisory now

This is the question an advisory note actually raises, and it needs six years of test history to answer. We followed the same vehicles from one MOT to the next across 2019–2024 and measured how often a component that was merely advised came back as a genuine failure at the next test.

Read it as a budgeting horizon, not a prophecy: the most likely component above turns into a failure for about 24 in 100 cars, and the median gap is 12.2 months and roughly 868 miles. The rest were repaired, sold, scrapped, or simply held. Rows with fewer than 500 tracked advisories are not shown.

What will fail next on a Daihatsu Hijet?

Lamps, reflectors and electrical equipment after a failure at age 15-19 are highest at 37.8%; Noise, emissions and leaks after a passed at age 20+ are lowest at 9.7% — the gap is 28.1 percentage points.

higher = more likelypercentage is the observed transition probability

The same chains, cut differently: given a car's age and how its last test went, which component most often causes trouble at the following one.

The pattern that repeats across every family: a failure at one test roughly doubles the chance of a failure on the same component at the next one, and an advisory sits about half-way between a clean pass and a failure. Age bands in years; probabilities are per car, not per defect item.

Daihatsu Hijet ownership: what six years of MOTs show

The ten-day re-test pass rate is highest at 69.9%; The later re-test pass rate is lowest at 11.4% — the gap is 58.5 percentage points.

higher = larger sharecompare shares in percentage points

Failing is usually a same-week event, not a disaster. Of 1,839 failures followed through to their re-test, 18.76% were repaired and passed the same day and 69.87% within ten days; the median gap is 3 days. 6,655 defect items were cleared in the process.

Per mile driven, not per year. Dividing failures by the miles that actually went onto the odometers between consecutive tests gives 2.046 failures per 10,000 miles, on a median of 886 miles a year across 1,433 chains. This is the number to compare between models — an annual rate quietly rewards cars that barely leave the drive.

Two populations hide inside one model. 27.49% of these cars strung together three or more tests with nothing recorded at all, while 37.89% carried the same advisory three times or more — the same fault, noted, ignored, noted again. When you buy used you are buying one of those two histories, and the MOT record shows which.

Odometer anomalies: 5.838% of 1,456 chains show a reading lower than the previous test, with a median drop of 20,798 miles. We call this an anomaly and not fraud on purpose — instrument swaps, imports, unit mix-ups and keying errors all land in the same bucket. Obvious typos (drops under 100 miles or over 90% of the reading) are already excluded.

Daihatsu Hijet safety recalls and how to check yours

DVSA recall campaigns stand out at 7.

bigger number = more recorded casescompare like-for-like scope, not sample size alone

recall campaigns launched per year

DVSA lists 7 safety recall campaigns for the Daihatsu Hijet, covering roughly 31,245 vehicles in total. A recall is the manufacturer fixing a fault for free, so an open recall on your car costs nothing to clear.

Counter-intuitive, and measured on our own data: across the 25 families published here, more recalls go with a lower MOT Risk Index (r = −0.52). Heavily recalled models are not worse cars in the test bay — an active manufacturer removes the fault before it becomes an MOT failure.

Check whether a specific car has an outstanding recall — free, by registration — at DVSA's recall service. Source: DVSA vehicle safety recalls (check-vehicle-recalls.service.gov.uk), OGL.

Daihatsu Hijet MOT: quick answers

Daihatsu Hijet MOT Risk Index stands out at 111.5, against 100 for a car with the same age profile.

below 100 is betterabove 100 is worse100 = normal for this model at that age

What is the Daihatsu Hijet first-time MOT pass rate?

58.2% of first attempts passed in 2024 (909 tests). This is the first-time figure: retests after repair are excluded. Basis: first-time, excluding retests.

Why does this number differ from other sites?

Other sites often report a pass rate that includes retests or counts all attempts. Our 41.8% figure is the first-time initial failure rate, using 909 primary tests as the denominator (first-time, excluding retests). The age-adjusted MOT initial-failure ratio 111.5 is shown separately because raw rates compare fleet age as well as cars.

Compare the Daihatsu Hijet with other cars

Chrysler Ypsilon is highest at 111.7; Peugeot 306 is lowest at 111.4 — the gap is 0.3 points.

below 100 is betterabove 100 is worse100 = normal for this model at that age

Same brand

All Daihatsu MOT statisticsDaihatsu Fourtrak MOT statsDaihatsu Charade MOT stats

Similar risk

Peugeot 306 (index 111.4)Volkswagen Polo (index 111.6)Chrysler Ypsilon (index 111.7)

Same size class

how Subaru BRZ compareshow Skoda Felicia compareshow Bentley Mulsanne compares

By area

Daihatsu Hijet MOT failure rate by postcode area

By failure group

Daihatsu Hijet body, chassis and structure failuresDaihatsu Hijet brakes failuresDaihatsu Hijet vehicle identification failuresDaihatsu Hijet lamps, reflectors and electrics failuresDaihatsu Hijet noise, emissions and leaks failuresDaihatsu Hijet seat belts and airbags failuresDaihatsu Hijet steering failuresDaihatsu Hijet suspension failuresDaihatsu Hijet tyres failuresDaihatsu Hijet visibility failures